Product ID:WHITE LITHIUM GREASE, WG-16
MSDS Date:03/16/1993
FSC:9150
NIIN:00N070661
MSDS Number: CBMHT

MASTER CORP

GERMANTOWN, TN 38183-1900
US

Emergency Phone: 800-255-3924

Info Phone: 901-755-5555

Preparer: E.S.P.

Cage: MASTC

MASTER CORP

381900 GERMANTOWN, TN 38138-1900 US

Telephone: 901-755-5555

Cage: MASTC

RUBBER SOLVENT (NAPHTHA SOLVENT REFINED, LIGHT); (PETROLEUM

CAS: 64741-84-0

Fraction By Weight: 11%

OSHA PEL N/K

ACGIH TLV: 400 PPM (MFR)

10

CAS: 64742-89-8

Fraction By Weight: 5%

OSHA PEL 300 PPM (MFR)

ACGIH TLV: 200 PPM (MFR)

1640 @ 68F.

CAS: 106-97-8

RTECS: EJ4200000

Fraction By Weight: 7%

OSHA PEL 800 PPM

ACGIH TLV: 800 PPM

6850 @ 68F.

CAS: 74-98-6

RTECS: TX2275000

Fraction By Weight: 8%

OSHA PEL 1000 PPM

ACGIH TLV: ASPHYXIANT

& FULL LENGTH FACESHIELD .

RTECS: 9999999ZZ

SOLVENT RESISTANT APRONS OR OTHER CLOTHING

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:ACUTE:EYE/SKIN IRRITANT.
INHALATION:RESPIRATORY IRRITATION, HEADACHE, NAUSEA, FATIGUE,
DROWSINESS, IMPAIRED CO-ORDINATION. SKIN:CONTACT MAY DRY SKIN;
PROLONGED CONTACT MAY CAUSE IRRITATION. EYES:LIQUI D OR VAPOR CAN
IRRITATE. SKIN ABSORPTION:CAN BE ABSORBED, SOLVENT ACTION CAN DRY &
DEFAT SKIN CAUSING (EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZ:SKIN TO CRACK, LEADING TO DERMATITIS.
INGESTION:NOT A LIKELY ROUTE OF EXPOSURE. CHRONIC:UNKNOWN.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHAL:REMOVE TO FRESH AIR. SUPPORT BREATHING (GIVE O*2/ARTF
RESP) . EYES:IMMEDIATELY FLUSH W/POTABLE WATER FOR A MINIMUM OF 15
MINUTES, SEEK ASSISTANCE FROM MD . SKIN:FLUSH W/COPIOUS AMOUN TS OF
WATER. CALL MD . INGEST:DO NOT INDUCE VOMITING. SEEK IMMEDIATE
MEDICAL ADVICE &/OR ATTENTION.

Extinguishing Media:FOAM, ALCOHOL FOAM, CO*2, DRY CHEMICAL, WATER FOG.
Fire Fighting Procedures:USE NIOSH/MSHA APPRVD SCBA & FULL PROT EQUIP.
WATER SPRAY MAY BE INEFT. WATER MAY BE USED TO COOL CNTNRS TO PVNT
PRESS BUILD-UP & EXPLO WHEN EXPOS(SUPDAT)
Unusual Fire/Explosion Hazard:CLSD CNTNRS MAY EXPLODE FROM INTERNAL
PRESS BUILD-UP WHEN EXPOS TO EXTREME HEAT & DISCHARGE CONTENTS. LIQ
CONTENT OF CNTNR WILL NOT SUPPORT COMBUST. (SUPP DATA)

Spill Release Procedures:AVOIID BREATHING VAPORS. VENTILATE AREA.
REMOVE ALL SOURCES OF IGNITION. CLEAN UP AREA W/ABSORBENT MATERIAL
& PLACE IN CLOSED CONTAINERS FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE & USE IN COOL, DRY,
WELL-VENTILATED AREAS. DO NOT STORE >120F. DO NOT PUNCTURE/INCIN
(BURN) CANS. DO NOT SPRAY IN EYES. DO NOT TAKE INTERNALLY.
Other Precautions:DO NOT STICK PIN, NAIL/ANY OTHER SHARP OBJECT INTO
OPENING ON TOP OF CAN. SEE PROD LABEL FOR ADDNL INFO. STORAGE OF
NON-FLAMM PRODS W/NON-FLAMM/FLAMM PRESSURIZING AGENT, IN CARTONS,
IS THE SAME AS FOR ORDINARY CANNED GOODS IN CARTONS.

Respiratory Protection:NONE UNDER NORMAL USE. AVOID BRTHG VAPS. IN
RESTRICTED AREAS, USE NIOSH/MSHA APPRVD CHEM/MECH FILTERS DESIGNED
TO REMOVE COMBINATION OF PARTICLES & VAP. IN CONFINED AREAS, USE
NIOSH/MSHA APPRVD AIR LI NE TYPE RESP/HOOD. NIOSH/MSHA (SUPDAT)
Ventilation:SUFFICIENT TO PVNT INHAL OF SOLV VAPS. GEN DILUTION &/OR
LOC EXHST VENT IN VOL/PATTERN TO KEEP PEL/TLV OF MOST (SUPDAT)
Protective Gloves:SOLVENT RESISTANT GLOVES.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS (ING 5)
Other Protective Equipment:EYE WASH FOUNTAIN & DELUGE SHOWER WHICH MEET
ANSI DESIGN CRITERIA . NONE UNDER NORMAL USE; HOWEVER, USE OF (ING
6)
Work Hygienic Practices:NONE SPECIFIED BY MANUFACTURER.
Supplemental Safety and Health
FIRE FIGHT PROC:TO EXTREME HEAT. IF WATER IS USED, FOG NOZZ PREF. EXPLO
HAZ:OVEREXP TO DECOMP PRODS MAY CAUSE HLTH HAZ. SYMPS MAY NOT BE
READILY APPARENT. OBTAIN MED ATTN. RESP PROT:APPRVD SCBA IS REQ D
FOR VAP CONCS ABOVE PEL/TLV LIMS. VENT:HAZ INGS BELOW ACCEPT LIMIT
& LEL BELOW STATED LIMIT.

Vapor Pres:SEE INGS
Solubility in Water:COMPLETE
Appearance and Odor:AEROSOL PRODUCT.

Stability Indicator/Materials to Avoid:YES
OXIDIZING AGENTS.
Stability Condition to Avoid:APPLICATION TO HOT SURFACES. STORAGE ABOVE
120F. EXPOSURE TO OPEN FLAME.
Hazardous Decomposition Products:MAY PRODUCE FUMES WHEN HEATED TO
DECOMPOSITION. FUMES MAY CONTAIN CARBON MONOXIDE.

Waste Disposal Methods:DISPOSE OF I/A/W LOCAL, STATE & FEDERAL
REGULATIONS. BEFORE ATTEMPTING CLEAN UP, REFER TO OTHER SECTIONS OF
THIS MSDS FOR HAZARD CAUTION INFORMATION.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.